VW Avant RS2 1994 Workshop Manual (Edition 03.1994)
VW Avant RS2 1994 Workshop Manual (Edition 03.1994) PDF free online
CONTENTS
- Current Flow Diagrams Avant RS2
- Relay position assignment
- Immobilizer
- Motronic control unit, trailer recognition
- Motronic control unit, heated rear window
- Turn signal and hazard warning flasher system, licence plate light
- Bulb monitoring device, trailer coupling
- Trailer coupling, rear fog lamp
- Electrically adjustable driver and front passenger mirror
- All other non-Avant RS2 specific current flow diagrams => Workshop Manual Audi 80 Current Flow Diagrams, Electrical Fault Finding and Fitting Locations binder 1992 ►
- 00 Technical Data
- Engine number
- Engine features
- 01 Self-diagnosis
- Motronic self-diagnosis
- Fault table
- Basic setting of engine with V.A.G 1551
- For repair procedures below => Audi 80 1992 ► Motronic Fuel Injection and Ignition System (5-Cylinder)
- Interrogating and erasing fault memory with fault reader V.A.G 1551
- Final control diagnosis with fault reader V.A.G 1551
- Testing cable connection of diagnostic sockets
- Removing and installing Motronic control unit
- Connecting test box V.A.G 1598
- Reading measured value block
- Interrogating control unit version with V.A.G 1551
- Motronic self-diagnosis
- 10 Removing and Installing Engine
- 13 Crankshaft Group
- 15 Cylinder Head, Valve Gear
- 17 Lubrication
- 19 Cooling System
- 20 Fuel Supply System
- Dismantling and assembling fuel pump
- Testing delivery of fuel pump
- 21 Charging
- Removing and installing parts of charge air cooler
- Testing exhaust gas turbocharger and blow-off valve
- 24 Mixture Preparation, Injection
- Motronic components
- Technical data
- For repair procedures below => Audi 80 1992 ► Motronic Fuel Injection and Ignition System (5-Cylinder)
- Rules for cleanliness
- Safety precautions
- Repairing Motronic injection system
- Testing system pressure and holding pressure
- Testing injectors
- Testing altitude sender-F96
- Reduction in engine output when towing a trailer
- For repair procedures below => Audi 80 1992 ► Motronic Fuel Injection and Ignition System (5-Cylinder)
- Testing fuel pump relay and actuation
- Testing idle speed and CO content
- Testing idle speed stabilization
- Testing Lambda probe and lambda control
- Removing and installing lambda probe
- Testing solenoid valve for activated charcoal filter
- Testing solenoid valve for boost pressure limiter
- Testing and adjusting idle speed switch
- Testing and adjusting throttle valve potentiometer
- Testing air mass meter
- Testing auxiliary signal of air conditioner and compressor cutoff
- Testing auxiliary signal of air conditioner for increasing engine speed
- Testing actuation of on-board computer for fuel consumption display
- Testing road speed signal
- Testing actuation of revolution counter
- Testing output signal for throttle valve position
- Testing auxiliary signal for reducing boost pressure when engine hot
- Pressure connections
- Motronic components
- 26 Exhaust System
- Removing and installing exhaust system
- Aligning exhaust system free of tension
- Checking exhaust system for leaks
- 28 Ignition System
- For repair procedures below => Audi 80 1992 ► Motronic Fuel Injection and Ignition System (5-Cylinder) Motronic components
- Replacing wheel bearing housing
- Removing and installing suspension strut and drive shaft
- 42 Rear Suspension
- Replacing wheel bearing housing
- Removing and installing drive shaft
- 44 Wheels, Tyres, Wheel Alignment
- Fitting tyres
- Wheels and tyres
- Winter tyres
- For repair procedure below =» Audi 80 1992 ► Running Gear 4WD Wheel alignment
- 45 Anti-locking Brake System
- Removing and installing ABS components on front axle
- Removing and installing ABS components on rear axle
- 46 Brakes, Brake Mechanics
- Servicing front brakes
- Inspecting brake pad thickness
- Replacing brake pads
- Installing
- Running in brake pads
- Servicing rear brakes
- Servicing handbrake
- Removing and installing handbrake cables
- Adjusting handbrake
- For repair procedure below => Audi 80 1992 ► Running Gear 4WD Removing and installing pedal group, servicing pedal group
- Servicing front brakes
- 47 Brakes, Brake Hydraulics
- Servicing four-piston fixed-caliper brake system
- For repair procedures below => Audi 80 1992^ Running Gear 4WD Removing and installing brake master cylinder/brake servo unit Bleeding brake system and changing brake fluid Location of brake pressure regulator
- Servicing four-piston fixed-caliper brake system
Language: English
Format: PDF
Pages: 66
VW Avant RS2 1994 Workshop Manual (Edition 03.1994) PDF free online