Geely CK 2008 Workshop Manual
2008 Geely CK Workshop Manual PDF
Table of Contents
- Part I Engine
- Chapter 1 Engine Assembly (MR479Q, MR479QA, MR481QA)
- Section 1 Routine Inspection
- Section 2 Drive Belt Replacement
- Section 3 Valve Clearance Adjustment
- Chapter 2 Engine Components Replacement (MR479Q, MR479QA, MR481QA)
- Section 1 Engine Components
- Section 2 Engine Components Replacement
- Section 3 Timing Belt Replacement
- Section 4 Camshaft Replacement
- Section 5 Cylinder Head Gasket Replacement
- Section 6 Oil Pump Oil Seal Replacement
- Section 7 Engine Rear Oil Seal Replacement
- Chapter 3 Lubrication System (MR479Q, MR479QA, MR481QA)
- Section 1 Oil Pressure Gage Sensor Replacement
- Section 2 Oil Pump Assembly Replacement
- Section 3 Oil Filter Replacement
- Section 4 Starter Replacement
- Section 5 Generator Replacement
- Chapter 4 Fuel System (MR7131A, MR7151A, MR7161A)
- Section 1 Check Fuel System Pressure
- Section 2 Fuel Pump Inspection
- Section 3 Fuel Injector Replacement
- Section 4 Fuel Pump Replacement
- Section 5 Fuel Emission Control System
- Section 6 C arbon Canister Replacement
- Chapter 5 Exhaust System (MR7131A, MR7151A, MR7161A)
- Chapter 6 Cooling System Inspection (MR7131A, MR7151A, MR7161A)
- Section 1 System Check
- Section 2 Water Pump, Thermostat and Radiator Replacement
- Chapter 7 Clutch (MR7131A, MR7151A, MR7161A)
- Section 1 Clutch Replacement
- Chapter 8 Maunal Transaxle Assembly (MR7131A, MR7151A, MR7161A)
- Section 1 Manual T ransaxle Replacement
- Section 2 Vehicle Speed Sensor Replacement
- Section 3 Transmission Case Oil Seal
- Section 4 Transaxle Case Oil Seal Replacement
- Chapter 9 General Engine Troubles and Their Troubleshooting
- Section 1 Overview
- Section 2 General Engine Fault and Troubleshooting
- Section 3 Engine Noise Diagnosis and Troubleshooting
- Chapter 10 Engine Management Unit
- Section 1 System Description
- Section 2 System Component and Working Principle
- Part II Chassis
- Chapter 1 Transmission Control Device
- Section 1 Transmission Control Device
- Section 2 Lever Type Transmission Control Device
- Section 3 Cable Type Transmissi on Control Module
- Chapter 2 Accelerator Pedal
- Section 1 Accelerator Pedal
- Chapter 3 Clutch Control System
- Section 1 Clutch Control System
- Section 2 Clutch Cable Control Mechanism
- Section 3 Clutch hydraulic Control Device
- Chapter 4 Propeller Shaft
- Section 1 Propeller Shaft
- Chapter 5 Front Suspension System
- Section 1 Front Suspension System
- Section 2 Front Suspension
- Section 3 Front Wheel Alignment
- Section 4 Front Strut Assembly
- Section 5 Lower Swing Arm Assembly
- Section 6 Front Stabilizer Bar and Link Rod Assembly
- Chapter 6 Rear Suspension System
- Section 1 Rear Suspension System
- Section 2 Rear Suspension
- Section 3 Rear Wheel Alignment
- Section 4 Left & Right Rear Strut Assembly
- Section 5 Rear stabilizer bar assembly, strut rod components
- Section 6 Left & Right Trailing Rod Assembly
- Section 7 No. 1 Transverse Arm Assembly
- Section 8 No. 2 Transverse Arm Assembly
- Chapter 7 Wheel
- Section 1 Tire Inspection
- Section 2 Wheel Replacement
- Chapter 8 Power Steering System
- Section 1 Power Steering System
- Section 2 Steering Drive and Control Mechanism
- Section 3 Steering Pipeline Component
- Section 4 Power Steering Gear Retaining Device
- Chapter 9 Brake System
- Section 1 Brake System
- Section 2 Brake Fluid
- Section 3 Brake Pedal
- Section 4 Vacuum Booster with Brake Master Cylinder Assembly
- Section 5 Front Brake Assembly
- Section 6 Rear Brake
- Section 7 Brake Line
- Section 8 Parking Brake System
- Chapter 1 Survey
- Chapter 2 Starting and Charging System
- Section 1 Starting System (MR479Q MR479QA MR481QA)
- Section 2 Charging System (MR479Q, MR479QA, MR481QA)
- Chapter 3 Combination Meter System
- Section 1 Circuit Diagram of Combination Meter and Location of Multi-pin Plug-in
- Terminal
- Section 2 Malfunction Symptom Table and Solution Procedure
- Section 3 Combination Meter
- Chapter 4 Wiper and Washer System
- Section 1 Wiper and Washer System Inspection
- Section 2 Replacement and Adjustment
- Chapter 5 Light System
- Section 1 Survey of Light System
- Section 2 Light System Symptom Inspection
- Section 3 Headlamp Replacement
- Section 4 Front Fog Lamp Replacement
- Section 5 Rear Combination Lamp Replacement
- Section 6 High Mounted Stop Lamp Replacement
- Section 7 Interior Dome Lamp Replacement
- Section 8 Rear Row Reading Lamp Replacement
- Section 9 License Plate Lamp Replacement
- Chapter 6 Audio System
- Section 1 Audio System Description
- Section 2 Audio System Connector Terminal Layout
- Section 3 Audio System Inspection
- Section 4 Audio and V ideo System Replacement
- Chapter 7 SRS (Supplemental Restraint System)
- Section 1 SRS-General Information
- Section 2 Troubleshooting
- Section 3 Removal & Installation
- Chapter 8 MK-20 ABS System
- Section 1 ABS Diagnosis
- Section 2 ABS System Check
- Section 3 Removal and Installation
- Part IV Air Conditioner and Inside & Outside Trim
- Chapter 1 A/C System
- Section 1 The Structure & Working Principle of Refrigeration System
- Section 2 Heating System
- Section 3 A/C contr olling system
- Section 4 Service Caution & Notice
- Section 5 The Refrigeration System Operation Procedure
- Section 6 Basic System
- Section 7 A/C System Faults Check & Troubleshooting
- Chapter 2 Inside & outside Trim and Accessory
- Section 1 Configuration Index
- (I) Outside Trim And Fr ont Accessory
- (II) Outside Trim and Rear Accessory
- (III) Front inside trim
- (IV) Rear inside trim
- Section 2 Inside & Outside Trim and Accessories Removal and Installation
- (I) Front Bumper
- (II) Engine Hood
- (III) Outside Rear View Mirror
- (IV) Rear trunk Lid
- (V) Rear Bumper
- (VI) Seat Removal, Installation and Adjustment
- (VII) Seat Belt
- (VIII) Instrument panel and auxiliary console
- (IX) A pillar inside trim and front door sill
- (X) B pillar inside trim
- (XI) Cpillar inside trim and rear door sill
- (XII) Roof inside trim
- (XIII) Carpet and Heat Insulator
- (XIV) Rear trunk Inside Trim
- (XV) Engine Hood Inside Trim
- (XVI) Door
- Part V Body
- Chapter 1 General Information
- Section 1 Body Structure
- Chapter 2 Body Repair
- Section 1 Body Damage Forms and Requirements for Repair
- Section 2 Typical Technology Of Body Panel Repair
- Section 3 Repair after Body Damage
- Section 4 Features and Composition of Automobile Body
- Section 5 Painting Technique after Body Repair
- Section 6 Service Data For Body
Language: English
Format: PDF
Pages: 392